WELCOME ADVANCE FLYING ACADEMY
ROBINSON R22 FULL PILOT TRAINING COURSE STEP BY STEP
CLEANING HELICOPTER
CLEANING EXTERIOR SURFACES
The helicopter should be washed with mild soap and water. Harsh abrasives, alkaline soaps, or detergents could scratch painted or plastic surfaces or could cause corrosion of metal. Cover areas where cleaning solution could cause damage. Use the following procedure:
1. Rinse away loose dirt with water.
2. Apply cleaning solution with a soft cloth, sponge, or soft bristle brush.
3. To remove stubborn oil and grease, use a cloth dampened with aliphatic naphtha.
4. Rinse all surfaces thoroughly.
5. Any good automotive wax may be used to preserve painted surfaces. Soft cleaning cloths or a chamois should be used to prevent scratches when cleaning or polishing.
CAUTION
Never use high-pressure spray to clean helicopter. Never blow compressed air into main or tail rotor blade tip drain holes.
CLEANING WINDSHIELD AND WINDOWS
1. Remove dirt, mud, and other loose particles from exterior surfaces with clean water.
2. Wash with mild soap and warm water or with aircraft plastic cleaner. Use a soft cloth or sponge in a straight back and forth motion. Do not rub harshly.
3. Remove oil and grease with a cloth moistened with isopropyl alcohol (rubbing alcohol) or aliphatic naphtha.
CAUTION
Do not use gasoline, other alcohols, benzene, carbon tetrachloride, thinner, acetone, or window (glass) cleaning sprays.
4. After cleaning plastic surfaces, apply a thin coat of hard polishing wax. Rub lightly with a soft cloth. Do not use a circular motion.
5. Scratches can be removed by rubbing with jeweler’s rouge followed by hand polishing with commercial plastic polish. Use a figure eight motion when polishing.
CLEANING UPHOLSTERY AND SEATS
1. Vacuum and brush, then wipe with damp cloth. Dry immediately.
2. Soiled upholstery, except leather, may be cleaned with a good upholstery cleaner suitable for the material. Follow manufacturer’s instructions. Avoid soaking or harsh rubbing.
CAUTION
If CO detector is installed, avoid use of solvents, detergents, or aerosol sprays near sensor. Tape off openings in top and bottom of sensor housing when cleaning cabin interior.
3. Leather should be cleaned with saddle soap or a mild hard soap and water.
CLEANING CARPETS
Remove loose dirt with a whisk broom or vacuum. For soiled spots and stains, use nonflammable dry cleaning liquid.
CLICK 👉 ROBINSON R22 HANDBOOK
CLICK 👉 PREFLIGHT INSPECTION
CLICK 👉 BEFORE STARTING ENGINE
CLICK 👉 STARTING ENGINE AND RUN-UP
CLICK 👉 SHUTDOWN PROCEDURE
CLICK 👉 FLIGHT AND MANEUVER LIMITATIONS
CLICK 👉 KINDS OF OPERATION LIMITATIONS
CLICK 👉 FUEL LIMITATIONS
CLICK 👉 POWER FAILURE - GENERAL
CLICK 👉 POWER FAILURE ABOVE 500 FEET AGL
CLICK 👉 POWER FAILURE BETWEEN 8 FEET AND 500 FEET AGL
CLICK 👉 EMERGENCY WATER LANDING – POWER OFF
CLICK 👉 EMERGENCY WATER LANDING – POWER ON
CLICK 👉 ROTOR SYSTEMS
CLICK 👉 DRIVE SYSTEM
CLICK 👉 POWERPLANT
CLICK 👉 FLIGHT CONTROLS
CLICK 👉 REMOVABLE FLIGHT CONTROLS
CLICK 👉 RPM GOVERNOR
CLICK 👉 CONTROL TRIM AND FRICTION
CLICK 👉 ENGINE CONTROLS
CLICK 👉 CLUTCH ACTUATOR
CLICK 👉 FUEL SYSTEM
CLICK 👉 ELECTRICAL SYSTEM
CLICK 👉 LIGHTING SYSTEM
CLICK 👉 AUDIO SYSTEM
CLICK 👉 OPTIONAL AVIONICS
CLICK 👉 PITOT-STATIC SYSTEM
CLICK 👉 DUAL TACHOMETER
CLICK 👉 WARNING AND CAUTION LIGHTS
CLICK 👉 CABIN HEATING AND VENTILATION
CLICK 👉 SEATS, BELTS, AND BAGGAGE
CLICK 👉 LANDING GEAR
CLICK 👉 ROTOR BRAKE
CLICK 👉 ENGINE PRIMER SYSTEM
CLICK 👉 CARBON MONOXIDE DETECTOR
CLICK 👉 EMERGENCY LOCATOR TRANSMITTER
CLICK 👉 OPTIONAL ACCESSORY MOUNTS
CLICK 👉 REQUIRED DOCUMENTS
CLICK 👉 REQUIRED INSPECTIONS
CLICK 👉 GROUND HANDLING
CLICK 👉 PARKING
CLICK 👉 CABIN DOORS
CLICK 👉 TAIL ROTOR GEARBOX OIL
CLICK 👉 BATTERY
CLICK 👉 CLEANING HELICOPTER
CLICK 👉 ALL AIRCRAFT TRAINING
CLICK 👉 ALL AIRCRAFT HANDBOOKS
CLICK 👉 ALL AIRCRAFT CHECKLISTS
CLICK 👉 NASA SPACECRAFTS BOOKS
CLICK 👉 ALL FIGHTER JETS HANDBOOKS
CLICK 👉 ALL HELICOPTERS HANDBOOKS
CLICK 👉 AIRBUS A320 COURSE
CLICK 👉 CESSNA 150 PILOT COURSE
CLICK 👉 CESSNA 152 COURSE
CLICK 👉 CESSNA 162 SKYCATCHER
CLICK 👉 CESSNA 172N SKYHAWK
CLICK 👉 CESSNA 172S COURSE
CLICK 👉 CESSNA 182T SKYLANE
CLICK 👉 ROBINSON R22 COURSE
CLICK 👉 ROBINSON R44 RAVEN II
CLICK 👉 PIPER ARCHER III PA-28-181 FULL COURSE